Product ID:THINNER, AIR CRAFT COATING
MSDS Date:10/01/1990
FSC:8010
NIIN:01-200-2637
MSDS Number: CCMJV

CSD, INC

CONROE, TX 77305
US

Emergency Phone: 409-756-1065

Info Phone: 409-756-1065

Preparer: DAVID SHIPP

Cage: 0LWP6

CSD, INC

687 CONROE, TX 77305 US

Telephone: 800-424-9300

Cage: 0LWP6

PROPYLENE GLYCOL MONOMETHYL ETHER

CAS: 107-98-2

RTECS: UB7700000

Fraction By Weight: 31%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150STEL;9596

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 52%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL;9596

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ISOBUTYL KETONE (HEXONE) (SARA 313) (CERCLA)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 17%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM/75 STEL; 9596

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:NOT GIVEN
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:MODERATE IRRITATION, REDNESS,
TEARING. SKIN:SLIGHT IRRIT. EXCESSIVE INHALE:CAN CAUSE NASAL &
RESPIRATORY IRRITATION & CENTRAL NERVOUS SYSTEM EFFECTS, DIZZINESS,
WEAKNESS, FATIGUE, NAUSEA, HEADACH ES & POSSIBLE UNCONSCIOUSNESS.
SWALLOWED:GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYES:MODERATE IRRITATION, REDNESS, TEARING.
SKIN:SLIGHT IRRITATION. EXCESSIVE INHALE:CAN CAUSE NASAL &
RESPIRATORY IRRITATION & CENTRAL NERVOUS SYSTEM EFFECTS, DIZZINESS,
WEAKNESS, FATIGUE, NAUSEA, HE ADACHES & POSSIBLE UNCONSCIOUSNESS.
SWALLOWED:GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING & DIARRHEA.
Medical Cond Aggravated by Exposure:METHYL ETHYL KETONE MAY ACCELERATE
ONSET OF PERIPHERAL NEUROPATHY CAUSED BY METHYL N-BUTYL KETONE.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. GIVE 1-2
GLASSES OF WA TER IF CONSCIOUS. GET MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:32.0F,0.0C
Lower Limits:1.7
Upper Limits:NOT GIVEN
Extinguishing Media:REGULAR FOAM OR WATER FOG OR CARBON DIOXIDE OR DRY
CHEMICAL
Fire Fighting Procedures:DO NOT USE TORCHES ON/NEAR DRUM(EVEN EMPTY)
RESIDUE CAN IGNITE. GROUND/BOND WHEN TRANSFERING MATERIAL. VAPOR
>THAN AIR, MAY TRAVEL/IGNITE AT DISTANT LOCATION
Unusual Fire/Explosion Hazard:WEAR SELF-CONTAINED BREATHING APPARATUS
WITH A FULL FACEPIECE OPERATED IN POSITIVE PRESSURE DEMAND MODE
WHEN FIGHTING FIRES.

Spill Release Procedures:SM:ABSORB LIQ ON PAPER,VERMICULITE,FLOOR
ABSORB. LG:ELIM ALL IGNITE SOURCES. REMOVE PERSONS NOT WEARING
PROTECTIVE EQUIP. STOP SPILL AT SOURCE. DIKE AREA, PREVENT SPREAD,
PUMP LIQ TO SALVAGE TANK, TAK E UP REMAINING W/SAND, ETC. SHOVEL
INTOCONTAINER
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTAINERS OF MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED SINCE EMPTY RETAINS RESIDUES(VAPOR, LIQ,
SOLID)ALL HAZARD PRECAUTIONS GIVEN MUST BE OBSERVED.
Other Precautions:WASH CONTAMINATED CLOTHING BEFORE REUSE.

Respiratory Protection:IF EXPOSURE LIMIT/COMPONENT IS
EXCEEDED:NIOSH/MSHA APPROVED AIR SUPPLIED RSPRTR IF NO
ENVIRONMENTAL CONTROL. OSHA REGS PERMIT OTHER NIOSH/MSHA
RSPRTR(NEGATIVE PRESSURE TYPE)(SEE SAFETY EQUIPMENT SUPPL IER &
ENGINEER/ADMINISTRATIVE CONTROLS)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL EXHAUST)
VENT TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:RESISTANT GLOVES SUCH AS NITRILE RUBBER
Eye Protection:CHEM SPLASH GOGGLES OR SAFETY GLASSES
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

HCC:F2
Boiling Pt:B.P. Text:175F/79.4C
Melt/Freeze Pt:M.P/F.P Text:-20F,-29C
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:49.1 MMHG
Vapor Density:3.4(AIR=1)
Spec Gravity:0.839
Evaporation Rate & Reference:16.8 (ETHYL ETHER=1)
Solubility in Water:MODERATE
Appearance and Odor:CLEAR, LITTLE IF ANY COLOR; CHARACTERISTIC ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS, CARBON
DIOXIDE AND CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:SMALL SPILL: DISPOSE OF IN ACCORDANCE WITH ALL
LOCAL, STATE & FEDERAL REGULATIONS. LARGE SPILL: DISPOSE OF IN
ACCORDANCE WITH ALL LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.